Product ID:M-BOND 610 ADHESIVE
MSDS Date:07/27/1999
FSC:8040
NIIN:00-117-7257
Status Code:A
Kit Part:Y
MSDS Number: CLGHR

MEASUREMENTS GROUP INC

9517 US 64 HWY
WENDELL, NC 27591
US

Emergency Phone: 800-424-9300

Info Phone: 919-365-3800

Preparer: RYAN MICKELSON

Cage: 88952

MEASUREMENTS GROUP INC

WENDELL, NC 27591 US

Telephone: 919-365-3800

Cage: 88952

TETRAHYDROFURAN

CAS: 109-99-9

RTECS: LU5950000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

PHENOL, POLYMER WITH FORMALDEHYDE, GLYCIDYL ETHER

CAS: 28064-14-4

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic: HEALTH HAZARDS (ACUTE AND CHRONIC):
CHRONIC OVER EXPOSURE MAY RESULT IN KIDNEY AND/OR LIVER DAMAGE.
Effects of Overexposure:INHALATION: MAY CAUSE HEADACHE, NAUSEA,
VOMITING, DIZZINESS, NARCOSIS, RESPIRATORY FAILURE, LOW BLOOD
PRESSURE, CENTRAL NERVOUS SYSTEM DEPRESSION, COUGHING, DIFFICULT
BREATHING. EYE CONTACT: MAY CAU SE SEVERE IRRITATION OR BURNS.
MAY CAUSE PAIN ON CONTACT. VAPORS MAY IRRITATE EYES. SKIN
CONTACT: MAY CAUSE SEVERE IRRITATION OR BURNS. ABSORPTION INTO THE
SKIN MAY CAUSE DERMATITIS. REPEATED CONTAC T MAY CAUSE DRYING OR
FLAKING OF SKIN. INGESTION: MAY CAUSE HEADACHE, NAUSEA, VOMITING,
DIZZINESS, GASTROINTESTINAL IRRITATION
Medical Cond Aggravated by Exposure:SKIN DISORDERS, RESPIRATORY SYSTEM
DISEASE

First Aid:INHALAITON: IF INHALED, MOVE TO FRESH AIR. IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE
OXYGEN. EYE CONTACT: IN CASE OF EYE CONTACT, IMMEDIATELY FLUSH EYES
WITH PLENT Y OF WATER FOR AT LEAST 15 MINUTES WHILE HOLDING EYELIDS
OPEN. SKIN CONTACT: IN CASE OF CONTACT, FLUSH SKIN WITH WATER WHILE
REMOVING CONTAMINATED CLOTHING. WASH AFFECTED AREA WITH SOAP AND
WATER. LAU NDER CONTAMINATED CLOTHING BEFORE REUSE. INGESTION: CALL
A PHYSICIAN. IF SWALLOWED, DO NOT INDUCE VOMITING UNLESS DIRECTED
TO DO SO BY A PHYSICIAN. IF CONSCIOUS, GIVE LARGE AMOUNTS OF WATER.

Flash Point Method:PMCC
Flash Point:=-14.4C, 6.F
Lower Limits:1.8
Upper Limits:11.8
Extinguishing Media: ALCOHOL FOAM, DRY CHEMICAL, CARBON DIOXIDE.
Fire Fighting Procedures:FIREFIGHTERS SHOULD WEAR PROPER PROTECTIVE
EQUIPMENT AND SELF-CONTAINED BREATHING APPARATUS WITH FULL
FACEPIECE OPERATED IN THE POSITIVE PRESSURE MODE. MOVE CONTAINERS
FROM FIRE AREA IF CAN BE DONE WI THOUT RISK. USE WATER TO KEEP
FIRE-EXPOSED CONTAINERS COOL.
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW ALONG SURFACES TO DISTANT
IGNITION SOURCE AND FLASH BACK. CLOSED CONTAINERS EXPOSED TO HEAT
MAY EXPLODE. CONTACT WITH STRONG OXIDIZERS MAY CAUSE FIRE. MAY FORM
EXPLOSIVE PEROXIDES, ESP ECIALLY WHEN HEATED.

Spill Release Procedures:WEAR SELF CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE CLOTHING. SHUT OFF INGNITION SOURCES; FLARES,
SMOKING OR FLAMES IN AREA. STOP LEAK IF YOU CAN DO SO WITHOUT RISK.
USE WATER SPRAY TO REDUCE VAPORS. TAKE UP WITH SAND OR OTHER NON
COMBUSTIBLE ABSORBENT MATERIAL AND PLACE INTO CONTAINER FOR LATER
DISPOSAL. FLUSH AREA WITH WATER.

Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY CLOSED. STORE
IN A COOL , DRY, WELL VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
KEEP PRODUCT OUT OF LIGHT.
Other Precautions:KEEP CONTAINERS TIGHTLY SEALED. AVOID PROLONGED
EXPOSURE TO VAPORS AND SKIN CONTACT.

Respiratory Protection:RESPIRATORY PROTECTION REQUIRED IF AIRBORNE
CONCENTRATION EXCEEDS TLV. AT CONCENTRATIONS UP TO 1000 PPM, A
CARTRIDGE RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE IS RECOMMENDED.
ABOVE THIS LEVEL, A SELF-CO NTAINED BREATHING APPARATUS IS
RECOMMENDED.
Ventilation:LOCAL EXHAUST: KEEP BELOW TLV
Protective Gloves:NEOPRENE GLOVES RECOMMENDED.
Eye Protection:CHEMCIAL SPLASH GOGGLES RECOMMENDED.
Other Protective Equipment:IMPERVIOUS OVER-CLOTHING AS NEEDED. SAFETY
SHOWER AND EYE WASH STATION IN LOCAL AREA.
Work Hygienic Practices:WASH THOROUGHLY AFTER USING.
Supplemental Safety and Health

Boiling Pt:=66.1C, 151.F
Vapor Pres:145@59 DEG F
Vapor Density:2.5
Spec Gravity:0.9
Evaporation Rate & Reference:14.5
Solubility in Water:APPRECIABLE
Appearance and Odor:COLORLESS LIQUID; ETHER LIKE ODOR
Percent Volatiles by Volume:712 G/LITER

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:POSSIBLE TOXIC GASES OR VAPORS.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIROMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.